棉渣堆肥过程理化性质变化及腐熟度评价

doi:10.3969/j.issn.1004-1524.2016.10.19

浙江农业学报 ›› 2016, Vol. 28 ›› Issue (10): 1764-1771.DOI: 10.3969/j.issn.1004-1524.2016.10.19

棉渣堆肥过程理化性质变化及腐熟度评价

刘岳贞¹, 陈倩倩¹, 陈晓旸², 洪春来², 陈林童¹, 鲁建江^{1, *}

1.石河子大学化学化工学院/新疆兵团化工绿色过程重点实验室,新疆石河子 832003;
2.浙江省农业科学院环境资源与土壤肥料研究所,浙江杭州 310021

收稿日期:2016-03-29 出版日期:2016-10-15 发布日期:2016-11-20
通讯作者: 鲁建江,E-mail:lujianjiang_xj@163.com
作者简介:刘岳贞(1987—),男,山东高唐人,硕士研究生,研究方向为环境化工。E-mail:liu_yuezheng@163.com
基金资助:
科技支疆计划项目(2013AB008)

Study on physicochemical properties and evaluation of maturity during composting of cotton slags

LIU Yue-zhen¹, CHEN Qian-qian¹, CHEN Xiao-yang², HONG Chun-lai², CHEN Lin-tong¹, LU Jian-jiang^{1, *}

1. School of Chemistry and Chemical Engineering, Shihezi University/Key Laboratory for Green Processing of Chemical Engineering, Xinjiang Production and Construction Corps, Shihezi 832003, China;
2. Institute of Environment, Resources, Soil & Fertilizer, Zhejiang Academy of Agricultural Sciences, Hangzhou 310021, China

Received:2016-03-29 Online:2016-10-15 Published:2016-11-20

摘要/Abstract

摘要： 对新疆特色农业废弃物棉渣进行堆肥化处置,以牛粪为调理剂,采用人工翻堆的方法进行高温好氧堆肥试验,研究添加牛粪对棉渣堆肥发酵的影响,探讨堆肥过程中不同部位物料理化性质的差异,并依据发芽指数(GI)评价物料的腐熟程度。结果表明,添加牛粪可以加速物料升温,提高主发酵温度,缩短发酵时间,添加牛粪处理的T值(终点C/N与初始C/N之比)比对照组提前12 d降到0.6以下,且发酵后GI较高,对植物毒性较小。不同部位温度的变化,以中层升温最快,温度最高。中层总有机碳(TOC)下降速率和总氮(TN)上升速率最快,深层次之,表层最慢。深层易形成厌氧区,物料腐熟较慢,堆肥腐熟之前深层GI最低,完全腐熟之后各层之间理化性质无显著差异。

关键词: 棉渣, 堆肥, 牛粪, 理化性质, 腐熟度

Abstract: Cotton slags, characteristic agriculture wastes in Xinjiang Province, were applied in the present study for composting. Cattle manure was added as conditioning agent to explore its effects on cotton slags composting, as well as to reveal the differences of physicochemical properties of material in different depths during composting. The maturity was evaluated on the basis of germination index (GI). It was shown that addition of cattle manure could accelerate the heating up of material, increase the primary fermentation temperature, and shorten the fermentation time. Compared with control, the T index (ratio between final and initial C/N) was reduced to 0.6 in advance of 12 d, and GI was increased with cattle manure added, indicating a lower phytotoxicity. The temperature in the middle layer rose the fastest and was the highest. The increase rate of TOC (total organic carbon) and decrease rate of TN (total nitrogen) in the middle layer was also the greatest, and was followed by the bottom layer and then the surface layer. Due to the easily generated anaerobic zone in the bottom layer, material decomposed slower there, and GI was the lowest before fully composting. After composting, there was no obvious difference of physicochemical properties in different depths.

Key words: cotton slags, compost, cattle manure, physicochemical properties, maturity

中图分类号:

X712

刘岳贞, 陈倩倩, 陈晓旸, 洪春来, 陈林童, 鲁建江. 棉渣堆肥过程理化性质变化及腐熟度评价[J]. 浙江农业学报, 2016, 28(10): 1764-1771.

LIU Yue-zhen, CHEN Qian-qian, CHEN Xiao-yang, HONG Chun-lai, CHEN Lin-tong, LU Jian-jiang. Study on physicochemical properties and evaluation of maturity during composting of cotton slags[J]. , 2016, 28(10): 1764-1771.

参考文献

[1] 汪晨霖, 耿钊, 李俊华, 等. 沼液与尿素配施对棉花产量及土壤重金属含量的影响[J]. 石河子大学学报(自然科学版), 2013 (5): 561-567.
WANG C L, GENG Z, LI J H, et al. Effect of combined application of biogas slurry and urea on cotton yield and heavy metal in soil [J]. Journal of Shihezi University ( Natural Science ), 2013 (5): 561-567. (in Chinese with English abstract)
[2] 朱凤香, 王卫平, 洪春来, 等. 接种复合菌剂对牛粪堆肥发酵的影响[J]. 浙江农业学报, 2012, 24(2): 275-278.
ZHU F X, WANG W P, HONG C L, et al. Effect of composite inoculants on fermentation of cow manure composting [J]. Acta Agriculturae Zhejiangensis , 2012, 24(2): 275-278. (in Chinese with English abstract)
[3] AGEGNEHU G, BASS A M, NELSON P N, et al. Benefits of biochar, compost and biochar-compost for soil quality, maize yield and greenhouse gas emissions in a tropical agricultural soil[J]. Science of the Total Environment , 2016, 543:295-306.
[4] VANDECASTEELE B, SINICCO T, D’HOSE T, et al. Biochar amendment before or after composting affects compost quality and N losses, but not P plant uptake[J]. Journal of Environmental Management , 2016, 168:200-209.
[5] JURAK E, PUNT A M, ARTS W, et al. Fate of carbohydrates and lignin during composting and mycelium growth of Agaricus bisporus on wheat straw based compost[J]. PLoS ONE , 2015, 10(10): e0138909.
[6] 吴珍珍, 舒增年, 黄健. 以菇渣和猪粪为调理剂的城市污泥堆肥效果研究[J]. 浙江农业学报, 2015, 27(12): 2171-2176.
WU Z Z, SHU Z N, HUANG J. Effect of mushroom residue and pig manure as conditioner on aerobic composting of sewage sludge[J]. Acta Agriculturae Zhejiangensis , 2015, 27(12): 2171-2176. (in Chinese with English abstract)
[7] 曹云, 常志州, 黄红英, 等. 畜禽粪便堆肥前期理化及微生物性状研究[J]. 农业环境科学学报, 2015, 34(11): 2198-2207.
CAO Y, CHANG Z Z, HUANG H Y, et al. Chemical and biological changes during early stage of composting of different animal wastes[J]. Journal of Agro-Environment Science , 2015, 34(11): 2198-2207. (in Chinese with English abstract)
[8] REUTER T, GILROYED B H, XU W, et al. Compost biodegradation of recalcitrant hoof keratin by bacteria and fungi[J]. Journal of Applied Microbiology , 2015, 119(2): 425-434.
[9] STANFORD K, REUTER T, GILROYED B H, et al. Impacts of sporulation temperature, exposure to compost matrix and temperature on survival of Bacillus cereus spores during livestock mortality composting[J]. Journal of Applied Microbiology , 2015, 118(4):989-997.
[10] 黄华, 黄懿梅, 刘学玲, 等. 覆盖处理对猪粪秸秆堆肥中氮素转化和堆肥质量的影响[J]. 环境科学学报, 2013, 33(3):780-786.
HUANG H, HUANG Y M, LIU X L, et al. Effect of covering on nitrogen transformation and the quality of pig manure straw compost[J]. Acta Scientiae Circumstantiae , 2013, 33(3): 780-786. (in Chinese with English abstract)
[11] 罗一鸣, 李国学, FRANK S, 等. 过磷酸钙添加剂对猪粪堆肥温室气体和氨气减排的作用[J]. 农业工程学报, 2012, 28(22): 235-242.
LUO Y M, LI G X, FRANK S, et al. Effects of additive superphosphate on NH 3 , N 2 O and CH 4 emissions during pig manure composting[J]. Transactions of the Chinese Society of Agricultural Engineering , 2012, 28(22): 235-242. (in Chinese with English abstract)
[12] 仇天雷, 高敏, 韩梅琳, 等. 鸡粪堆肥过程中四环素类抗生素及抗性细菌的消减研究[J]. 农业环境科学学报, 2015, 34(4): 795-800.
QIU T L, GAO M, HAN M L, et al. Decreases of tetracyclines and antibiotics-resistant bacteria during composting of chicken manure[J]. Journal of Agro-Environment Science , 2015, 34(4): 795-800. (in Chinese with English abstract)
[13] 田伟. 牛粪高温堆肥过程中的物质变化、微生物多样性以及腐熟度评价研究[D]. 南京:南京农业大学, 2012.
TIAN W. Study of substance change, microbial diversity and maturity assessment during thermophilic composting of dairy manure[D]. Nanjing: Nanjing Agricultural University, 2012. (in Chinese with English abstract)
[14] 张淑娟, 孟小春, 张旭兰. 城市污泥与餐厨垃圾好氧堆肥腐熟度快速评价指标研究[J]. 现代农业科技, 2014 (4): 204-206, 213.
ZHANG S J, MENG X C, ZHANG X L. Study of rapid assessment index of compost maturity of urban sludge and food waste[J]. Modern Agricultural Science and Technology , 2014 (4): 204-206, 213. (in Chinese)
[15] 鲍士旦. 土壤农化分析[M]. 北京: 中国农业出版社, 2000.
[16] 黄红英, 孙恩惠, 武国峰, 等. 麦秸秸秆花盆堆肥化研究及评价[J]. 农业环境科学学报, 2015, 34(12): 2386-2393.
HUANG H Y, SUN E H, WU G F, et al. Composting of wheat straw flowerpots and its evaluation[J]. Journal of Agro-Environment Science , 2015, 34(12): 2386-2393. (in Chinese with English abstract)
[17] 赵建荣, 高德才, 汪建飞, 等. 不同C/N下鸡粪麦秸高温堆肥腐熟过程研究[J]. 农业环境科学学报, 2011, 30(5): 1014-1020.
ZHAO J R, GAO D C, WANG J F, et al. The high-rate composting of chicken manure and wheat straw in different C/N[J]. Journal of Agro-Environment Science , 2011, 30(5): 1014-1020. (in Chinese with English abstract)
[18] 苏峰峰, 曾光明, 黄丹莲, 等. 胞外酶对堆肥中微生物群落演替的影响[J]. 中国环境科学, 2009, 29(5): 524-530.
SU F F, ZENG G M, HUANG D L, et al. Influence of extracellular enzymes on microbial community’s succession in composts[J]. China Environmental Science , 2009, 29(5): 524-530. (in Chinese with English abstract)
[19] SÁNCHEZ-MONEDERO M A, ROIG A, PAREDES C, et al. Nitrogen transformation during organic waste composting by the Rutgers system and its effects on pH, EC and maturity of the composting mixtures[J]. Bioresource Technology , 2001, 78(3):301-308.
[20] 李荣华, 张广杰, 张增强, 等. 添加木炭改善猪粪稻壳好氧堆肥工艺及质量[J]. 农业工程学报, 2014, 30(16): 230-238.
LI R H, ZHANG G J , ZHANG Z Q, et al. Improving pig manure and rice husk compost technology and quality by wood charcoal addition[J]. Transactions of the Chinese Society of Agricultural Engineering , 2014, 30(16): 230-238. (in Chinese with English abstract)
[21] KHAN N, CLARK I, SÁNCHEZ-MONEDERO M A, et al. Physical and chemical properties of biochars co-composted with biowastes and incubated with a chicken litter compost[J]. Chemosphere , 2016, 142: 14-23.
[22] 张聿柏, 李勤奋. 香蕉茎秆堆肥化处理腐熟度评价研究[J]. 中国农学通报, 2009, 25(9): 268-272.
ZHANG Y B, LI Q F. Study on evaluation of maturity during banana stem composting treatment[J]. Chinese Agricultural Science Bulletin , 2009, 25(9): 268-272. (in Chinese with English abstract)
[23] KOPE C ' M, GONDEK K, BARAN A. Assessment of respiration activity and ecotoxicity of composts containing biopolymers[J]. Ecotoxicology & Environmental Safety , 2013, 89(3):137-142.
[24] 王定美, 武丹, 李季, 等. 猪粪及其堆肥不同水浸提比对种子发芽特性指标的影响[J]. 农业环境科学学报, 2011, 30(3): 579-584.
WANG D M, WU D, LI J, et al. Effects of water extraction ratio of pig manure and its compost on seed germinative indicators[J]. Journal of Agro-Environment Science , 2011, 30(3): 579-584. (in Chinese with English abstract)

棉渣堆肥过程理化性质变化及腐熟度评价

Study on physicochemical properties and evaluation of maturity during composting of cotton slags

RichHTML

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics

本文评价

[1]	吴承杰, 任兰天, 郝冰, 邵庆勤, 王泓, 陈峰, 代高峰, 梅世远, 张从军. 秸秆堆肥部分替代化肥配施硝化抑制剂对冬小麦温室气体排放的影响[J]. 浙江农业学报, 2020, 32(7): 1233-1240.
[2]	马其雪, 孙向阳, 李素艳, 李松, 刘源鑫, 周文洁. 园林绿化废弃物堆肥对铅、锌污染土壤上小白菜生理特性的影响[J]. 浙江农业学报, 2020, 32(11): 2027-2034.
[3]	白玲, 宋飞跃, 季蒙蒙, 邓芸, 阮文权. 不同调理剂对秸秆沼渣堆肥的影响[J]. 浙江农业学报, 2020, 32(1): 124-133.
[4]	黄健, 肖建中, 唐世刚, 郑强, 丁枫华, 张东旭. 添加蒙脱石对猪粪好氧堆肥腐熟度和重金属钝化的影响[J]. 浙江农业学报, 2020, 32(1): 141-148.
[5]	周文志, 孙向阳, 李素艳, 张乐. 生物有机材料对滨海盐碱土的改良效果[J]. 浙江农业学报, 2019, 31(4): 607-615.
[6]	黄惠群, 蔡文昌, 张健瑜, 李灿, 曾和平. 炭化温度对牛粪生物炭结构性质的影响[J]. 浙江农业学报, 2018, 30(9): 1561-1568.
[7]	阮馨怡, 刘曦, 关玥, 孔海南, 林燕. 高效污泥降解菌种的筛选及在污泥堆肥中的效果[J]. 浙江农业学报, 2018, 30(9): 1569-1575.
[8]	杨颖, 唐伟敏, 陆胜民. 加工条件对细菌纤维素凝胶理化性质的影响[J]. 浙江农业学报, 2018, 30(4): 661-665.
[9]	王代懿, 余洋, 张丰松, 李性苑, 苟体忠. 堆肥方式和温度对牛粪堆肥过程中天然类固醇激素降解的影响[J]. 浙江农业学报, 2017, 29(12): 2104-2108.
[10]	肖翰, 刘标, 尹红梅, 许隽, 杜东霞, 贺月林. 病死猪堆肥高效油脂降解菌的筛选及堆肥效果研究[J]. 浙江农业学报, 2017, 29(1): 44-50.
[11]	徐多多, 王海洋, 孙濛濛, 韩苗苗, 赵鑫, 高其品. 平菇等六种食用真菌糖蛋白的理化性质及对顺铂诱导肾细胞损伤恢复的作用[J]. 浙江农业学报, 2016, 28(9): 1538-1543.
[12]	姜新有, 王晓东, 周江明, 郑建斌. 初始pH值对畜禽粪便和菌渣混合高温堆肥的影响[J]. 浙江农业学报, 2016, 28(9): 1595-1602.
[13]	聂冬1，金明姬2，*，刘永3，严昌国2. 牛粪与水稻秸秆混合厌氧发酵工艺优化及动力[J]. 浙江农业学报, 2016, 28(8): 1421-.
[14]	吴阳1，喻徐良1，徐乐中1，2，*，梅娟1. 城市污泥与园林绿化废弃物共堆肥效果研究[J]. 浙江农业学报, 2016, 28(5): 847-.
[15]	马闯，李明峰，赵继红*，张宏忠，魏明宝，叶长明. 调理剂添加量对污泥堆肥过程温度和氧气变化的影响[J]. 浙江农业学报, 2015, 27(4): 631-.